This guide aims to address potential causes and solutions for a Volkswagen CC door that refuses to open, whether from the inside or outside. The first step is to try to solve the door handle issue on any of the doors. Next, check the annoying roll pin, which can also be a cause. To replace the cable, you need to open up the inside panel and pull out the lock module.
To remove the driver’s side door handle, follow these steps: unscrew 3 trim screws, pull off the door panel starting at the bottom, lift the door panel so the door lock can fall through, and unplug the white plug leading to window switches. If you have the right tools and instructions, replacing the door handle on your VW is an easy DIY project.
The door latch can be removed by two screws in the side of the door, and the cable can be easily taken off and replaced. The handle should be installed further back and slide it forward so the piece the cable attaches to is behind the plastic piece it’s hitting. The cable can be adjusted according to the Haynes/Chilton manual. Twist the cable to shorten it, make sure it’s plugged into the door handle assembly correctly, and the cable is fully seated.
In 2002 Passat B5.5, the car went back to VW for a handle recall, where they said the drivers door cable had stretched, costing £140+ VAT for a cable.
📹 How To Remove A Volkswagen Passat CC Door Handle
Here are some cheap tools that I use daily in my workshop: Plastic removal tool: -11 pieces removal tool set (I have bought this …
📹 How to Replace Interior Door Handle Cable 10-14 Volkswagen GTI
In the video, 1A Auto shows how to remove, install, or replace a broken, snapped, rusted, or jammed door latch cable. The video is …
I have a problem with the same lock on the driver’s door. When I lock and unlock with the remote key, only one driver’s door will not open. sometimes when i lock and unlock again they open. I can always open them when I use the mechanical key. like the lock won’t always open. more and more often it won’t open. it is a Skoda Superb 2009. Does anyone have any ideas before I go to the mechanic. help please
Hi, I am having all sorts of trouble with my VW golf mk6 2010. The rear door doesn’t open from the inside and i have tried to take the panel off but it has another plastic panel under it which looks like the one on the right in this article but doesnt have the seperate part to get into where you are showing? its the one on the right but the full way across, if that makes sense!